Free cortisol and free 21-deoxycortisol in the clinical evaluation of congenital adrenal hyperplasia ==================================================================================================== * Bas P.H. Adriaansen * Agustini Utari * André J. Olthaar * Rob C.B.M. van der Steen * Karijn J. Pijnenburg-Kleizen * Lizanne Berkenbosch * Paul N. Span * Fred C.G.J. Sweep * Hedi L. Claahsen-van der Grinten * Antonius E. van Herwaarden ## Abstract **Context** Some patients with classic congenital adrenal hyperplasia (CAH) survive without glucocorticoid treatment. Increased precursor concentrations in these patients might lead to higher free (biological active) cortisol concentrations by influencing the cortisol-protein binding. In 21-hydroxylase deficiency (21OHD), the most common CAH form, accumulated 21-deoxycortisol (21DF), a precursor steroid, may further increase glucocorticoid activity. Both mechanisms could explain the low occurrence of symptoms in some untreated classic CAH patients. **Objective** Establishment and validation of an LC-MS/MS method for (free) cortisol and (free) 21DF to quantify these steroids in untreated patients with classic CAH (n=29), non-classic CAH (NCCAH, n=5), other forms of adrenal insufficiency (AI, n=3), and controls (n=11) before and 60 minutes after Synacthen® administration. **Results** Unstimulated total cortisol levels of untreated classic CAH patients (median 109 nmol/L) were lower compared to levels in untreated NCCAH patients (249 nmol/L, p=0.010) and controls (202 nmol/L, p=0.016), but free cortisol concentrations were similar. Basal free 21DF levels were high in 21OHD patients (median 5.32 nmol/L) and undetectable in AI patients and controls (<0.19 nmol/L). After Synacthen® administration, free concentrations of 21DF -but not cortisol-increased only in patients with 21OHD. **Conclusions** Free cortisol levels were similar in classic CAH compared to controls and NCCAH patients, suggesting a comparable availability of cortisol. Additionally, 21OHD patients produce high levels of the glucocorticoid 21DF, possibly explaining the low occurrence of symptoms in some classic 21OHD patients. Free cortisol and (free) 21DF levels should be considered in the clinical evaluation of adrenal insufficiency in patients with CAH. Keywords * ACTH * CAH * cortisol * free cortisol * 21-deoxycortisol * free 21-deoxycortisol ## Introduction Glucocorticoids, like cortisol, are among others essential for maintaining blood pressure, glucose metabolism, and modulating the immune response [1, 2]. Cortisol is produced by the adrenal cortex and has a diurnal rhythm with the highest concentration in the early morning [3]. The hypothalamus regulates this rhythm by stimulating the pituitary gland, which subsequently produces adrenocorticotropic hormone (ACTH). Negative feedback by cortisol balances the activity of the hypothalamus-pituitary-adrenal (HPA) axis. During periods of physical stress, such as infection or surgery, the demand for cortisol increases, which is mediated by an increased ACTH release. Patients with primary adrenal insufficiency (PAI) have insufficient cortisol production and are unable to increase cortisol levels during periods of stress. This leads to symptoms of cortisol deficiency such as extreme fatigue, weight loss, and abdominal pain. In adults, PAI is most often caused by acquired conditions such as auto-immune adrenalitis, known as Addison’s disease. In children, PAI is generally caused by inherited conditions affecting adrenal steroid production. The most common inherited form of PAI is classic congenital adrenal hyperplasia (CAH) caused by an enzyme deficiency in the adrenal steroidogenesis pathway. Most CAH patients have 21-hydroxylase deficiency (21OHD) (90 – 95%) or 11-hydroxylase deficiency (11-OHD) (∼5%). These patients have insufficient cortisol production and consequently, a reduced negative feedback to the pituitary gland, causing chronically elevated ACTH levels. This leads to continuous activation of the adrenal cortex and accumulation of precursor steroids before the enzymatic block. These precursor steroids are partly shunted into the unaffected adrenal androgen pathway, leading to hyperandrogenism. So, in contrast to other forms of PAI, the hallmark of classic CAH is not only a decreased concentration of cortisol but also strongly elevated concentrations of precursor steroids and adrenal androgens. Patients with non-classic CAH (NCCAH), a less severe subgroup, generally produce normal concentrations of cortisol but still have elevated concentrations of precursor steroids and androgens [4]. The first step in diagnosing PAI is measuring morning total cortisol concentrations in blood. To evaluate the potential responsiveness of the HPA axis to stress, stimulation tests are performed, such as the insulin tolerance test (ITT) [5] or the Synacthen® test [6]. In these tests, a suboptimal cortisol response is defined as a total cortisol concentration <500 nmol/L (18 μg/dL) [7], but there is an ongoing debate on this threshold [8]. In the CAH guideline, the cut-off is defined as <400 – 500 nmol/L (<14 – 18 μg/dL), depending on the measuring method [9]. Cortisol is in blood mostly bound to proteins (±95%), such as corticosteroid-binding globulin (CBG) and albumin [10, 11]. The measured total cortisol is comprised of the bound and free (i.e., unbound) cortisol, while, according to the free hormone hypothesis, only the latter determines the biological glucocorticoid activity [12]. In addition, patients with 21OHD have elevated levels of 17-hydroxyprogesterone (17OHP) that can be metabolized by 11-hydroxylase into 21-deoxycortisol (21DF) [13]. Interestingly, previous studies have described untreated classic CAH patients with insufficient cortisol production without overt complaints of cortisol deficiency [14–17]. Our group showed that 21DF can transactivate the glucocorticoid receptor with a relative potency of 49% compared to cortisol, the most potent endogenous glucocorticoid. Hence, 21DF contributes to the glucocorticoid activity, especially when the concentration is significantly increased, such as in patients with 21OHD [14]. In addition, it is known that precursor steroids can bind to CBG [11, 18, 19], thereby competing with cortisol for bindings spots on CBG and preventing cortisol from binding, therewith increasing the free fraction of cortisol. These mechanisms might contribute to the attenuation of symptoms in patients with untreated classic CAH. So far, no studies have been conducted on free cortisol and free 21DF measurements in patients with CAH. Our aim is to quantify total and free concentrations of cortisol and 21DF in the morning and 60 minutes after administration of Synacthen® in patients with untreated classic CAH (both 11OHD and 21OHD). We will compare these results with patients with NCCAH, patients with adrenal insufficiency (AI) but not CAH, and controls to investigate the situation of CAH patients in more detail. We hypothesize that free cortisol and (free) 21DF concentrations might give a better reflection of the glucocorticoid activity in patients with 21OHD compared to solely measuring total cortisol levels. ## Materials and methods ### Subjects This study was approved by the local medical ethics committee (Radboudumc, case number 2021-12944). Patients were included via three routes (see Figure S1): * (I) Indonesian cohort (n=22): Serum samples from an Indonesian cohort of untreated classic CAH patients (21OHD, n=17; 11OHD, n=5) were obtained as previously described [14]. Ethical approval was obtained from the ethical committee of the Faculty of Medicine, Diponegoro University, Semarang, Indonesia (713/EC/FK-RSDK/2016). * (II) Dutch retrospective cohort (n=39): Stored residual serum samples from Synacthen® tests performed between January 2016 and March 2021 were retrospectively collected. * (III) Dutch prospective cohort (n=19): Residual serum and plasma samples were obtained from three hospitals in the Netherlands between April 2021 and January 2024. For the Synacthen® tests, blood was obtained before (T) and 60 minutes after (T60) administration of 250 μg Tetracosactide. Samples were kept frozen at ≤ −30 °C until analysis. Inclusion criteria were: ≥300 µL residual serum available and patients not treated with systemic glucocorticoids for at least one year before blood withdrawal. Pseudonymized data about age, gender, time of blood withdrawal, indication of Synacthen® test, and diagnosis were collected. Patients were divided into four groups: (I) patients with classic CAH (both 21OHD and 11OHD), (II) patients with NCCAH based on 21OHD, (III) patients with adrenal insufficiency (AI) but not CAH, and (IV) patients with an optimal cortisol response after Synacthen® (controls). Classification of CAH patients in classic CAH and NCCAH was based on clinical characteristics, biochemical evaluation, and genetic analysis (Table S1) [20, 21]. Sequencing results were compared to the reference sequence GenBank [NM\_000500.9](http://medrxiv.org/lookup/external-ref?link_type=GEN&access_num=NM_000500.9&atom=%2Fmedrxiv%2Fearly%2F2024%2F07%2F11%2F2024.07.11.24310065.atom) for *CYP21A2* and NM_000497.3 for *CYP11B1*. In this article the term ‘classic CAH’ refers to both 21OHD and 11OHD patients. ### Measurement of total steroid concentrations with LC-MS/MS Total serum 17OHP (17-hydroxypregn-4-ene-3,20-dione), 11-deoxycortisol (17,21-dihydroxypregn-4-ene-3,20-dione), 21DF (11,17-dihydroxypregn-4-ene-3,20-dione), and cortisol (11,17,21-trihydroxypregn-4-ene-3,20-dione) were analyzed by a clinically validated liquid chromatography tandem mass spectrometry (LC-MS/MS) method on a 6490 triple quadrupole LC-MS/MS (Agilent Technologies, Santa Clara, CA) preceded by protein precipitation and solid phase extraction (SPE). An internal standard mix (20 µL in methanol:H2O 30:70) containing [13C3]-17OHP, [2H5]-11-deoxycortisol, [2H4]-21DF, and [13C3]-cortisol (all from Isosciences, Ambler, PA) with concentrations of 10, 10, 20, and 100 nmol/L, respectively, was added to 100 µL serum. For protein precipitation, acetonitrile + 0.1% formic acid was added and incubated for at least 10 minutes at room temperature and centrifuged (10 min, 5000g). Then, 200 μL supernatant was added to 300 μL H2O followed by SPE using Oasis® HLB 1cc cartridges (Waters Corporation, Milford, MA). These cartridges were preequilibrated with 1 mL methanol:isopropanol (95:5) and consequently washed with 1 mL H2O. After sample application, columns were washed with 1 mL H2O and 1 mL methanol:H2O (30:70). The eluate (300 μL, methanol:isopropanol 95:5) was dried under a stream of N2 gas at 40 °C, reconstituted in 100 μL methanol:H2O (30:70) and injected (10 µL) into an Agilent Technologies 1290 Infinity UHPLC-system (Agilent Technologies). LC-MS/MS settings are shown in Table S2. The collision energy was optimized for each analyte and internal standard and two mass transitions (quantitative and qualitative) were monitored. A nine-point calibration curve with 17OHP, 11DF, 21DF, and cortisol (all from Sigma-Aldrich, St. Louis, MO, USA) was used for quantification. The calibration ranges were 0 – 167 nmol/L for 17OHP, 0 – 191 nmol/L for 11DF, 0 – 167 nmol/L for 21DF, and 0 – 2,299 nmol/L for cortisol. In-house quality controls of human serum were measured in duplicate in each run. ### Measurement of free steroid concentrations with LC-MS/MS Measurement of free 21DF was incorporated in a clinically validated measuring method for free cortisol and free testosterone. Equilibrium dialysis was performed with samples buffered to pH 7.4 (± 0.03) at 37 °C (± 0.5) by a previously described HEPES buffer (4-(2-Hydroxyethyl)piperazine-1-ethanesulfonic acid; Merck, Rahway, NJ, USA) that resembled the ionic environment of serum [22]. Two identical volume compartments (180 μL) were separated by a semipermeable regenerated cellulose membrane (Serva Electrophoresis GmbH, Heidelberg, Germany) with a diameter of 28 mm and maximum permeability of 5 kDA. During dialysis, cells were placed in a water bath at 37 °C (± 0.5) for 5h while continuously rotating. After dialysis, dialysate was emptied from the cell and SPE was performed with 100 μL preceded by the addition of H2O (30 μL) and an internal standard mix (20 μL) containing [2H4]-21DF, [13C3]-cortisol, and [13C3]-testosterone (all from IsoSciences). For SPE, Oasis® MCX 1cc cartridges (Waters Corporation) were preequilibrated with 1 mL methanol:isopropanol (95:5) and consequently washed with 1 mL H2O. After sample application, columns were washed with 1 mL H2O + 5% ammonium hydroxide and 1 mL methanol:H2O (20:80) + 2% formic acid. The eluate (300 μL, 100% methanol) was dried in the Savant™ SpeedVac™ Concentrator (ThermoFisher Scientific, Waltham, MA, USA) for ± 1h, reconstituted in 30 μL methanol:H2O (30:70) and injected (10 µL) into a Xavi® TQ-XS StepWave XSTM triple quadrupole spectrometer (Waters Incorporation). LC-MS/MS settings including collision energy and mass transitions are shown in Table S3. A nine-point calibration curve with 21DB (Steraloids, Newport, RI, USA), 21DF, and cortisol (both from Sigma-Aldrich) was used for quantification. The calibration ranges were 0 – 115 nmol/L for all three steroids. ### Method validation All measurements were performed in an ISO15189 accredited laboratory. All clinically validated measuring methods are monitored for quality in each run using in duplicate measurements of in-house quality controls of human serum. For validation, a CLSI EP6 protocol [23] in serum was used to assess linearity. We measured steroid concentrations in a blank sample that was injected after the highest standard to assess carry-over. Ion suppression was measured according to CLSI C62-A guideline [24]: qualitative ion suppression by continuous infusion of the labeled steroid, and quantitative ion suppression by comparing the signal of human serum measurements (n=5) with the signal of spiked prepared matrix-free blank. Imprecision was assessed by a modified CLSI EP5 protocol [25] with pooled human serum samples at a low (n=7 for 21DF; n=20 for cortisol) and high concentration (n=8 for 21DF, n=20 for cortisol). The lower limit of quantification (LLOQ) was defined as the lowest concentration with an inter-assay coefficient of variation (CV) <20% and was determined with a modified EP evaluator protocol from pooled serum by between-day assay repeated measurements (n=10). For 21DF, recovery was calculated in five samples to which 29.94 nmol/L was added. For cortisol, a National Institute of Standards and Technology (NIST) standard (LOT number: 271020) diluted to 1.496 nmol/L was measured each run (n=29). A correction factor of 1.03 was applied to adjust free cortisol levels according to the NIST standard. Possible interfering substances were identified by measuring commercially available steroids and anti-androgens with a molecular mass ≤2 g/mol lower than the analyte or the internal standard. First, retention time interference was checked, and second, MRM transition interference was evaluated. ### Data and statistical analyses Free cortisol percentage was calculated by dividing the free cortisol concentration by the total cortisol concentration from the same sample multiplied by 100%. Since cortisol has a diurnal rhythm, only morning samples (between 08.00 – 11.00 AM) were used for the analyses of absolute free and total cortisol concentrations. Results